Washington State University
SAFETY POLICIES AND PROCEDURES MANUAL

CHEMICAL / HAZARDOUS MATERIAL SAFETY
5.62
Revised 8-00
Reviewed 9-03
Environmental Health and Safety
335-3041

Chemical Spill Control

PDF link

REPORTING SPILLS
When chemicals are spilled or are otherwise released from containment, the laboratory or shop supervisor is responsible for ensuring that releases are appropriately reported, cleaned up, and disposed of.
Applicability
This section includes procedures for reporting, containing, cleaning up, and disposing of uncontrolled releases of chemicals.
Radioactive Materials
This procedure does not apply to spills of radioactive substances. During working hours, contact the Radiation Safety Office for assistance with radioactive releases; telephone 335-8916. Telephone 911 or the Facilities Services, Operations dispatcher at 335-9000 during evenings and weekends.

Refer to 9.40 for decontamination procedures for radioactive substances.
Biohazardous Materials
This procedure does not apply to spills, releases, or improper disposal of biological materials, e.g., biohazard waste, dead animals. Call 911 or the local county/area emergency response number for assistance with these releases. See 4.24.
When to Ask for Help
The supervisor immediately determines whether or not his or her staff in the work area are capable of managing the release.

For assistance, Pullman campus units contact the Pullman Fire Department and Environmental Health and Safety (EH&S) by calling 911. Non-Pullman campus units contact the local fire department or the local county/area emergency response number.

Seek assistance if any of the following conditions exist:
Calling for Help

Pullman Campus/Whitman County
If the Pullman campus or Whitman County work area staff are not capable of managing a chemical spill or release, evacuate personnel from the affected area and telephone 911 to report the spill or release.

Keep personnel from re-entering the affected area.

Pull the fire alarm if the circumstances are serious or grave.

NOTE: If mercury is spilled in a nonpublic area at WSU Pullman or Whitman County during normal working hours, do not call 911. Contact EH&S; telephone 335-3041. A nonpublic area is a room to which access can be controlled by some means, i.e., a door. A public area is an area such as a hallway, lobby, or sidewalk.
Emergency Call
When placing a 911 emergency call, provide the following information to the dispatcher:
Answer any questions from the dispatcher.
Non-Whitman County Location
If the non-Whitman County location work area staff are not capable of managing a chemical spill or release, evacuate personnel from the affected area and telephone the local county/area emergency response number to report the spill or release.

Keep personnel from re-entering the affected area.

Pull the fire alarm if the circumstances are serious or grave.
Emergency Call
When placing a call to the local county/area emergency response number, provide the following information to the dispatcher:
Answer any questions from the dispatcher.
SPILL PROCEDURES

Who May Clean Up Spills
Personnel who work in the immediate area of a chemical spill, are familiar with the chemical, and are trained to safely contain and clean up chemical releases may clean up the spill. (WAC 296-62-41063) Typically, lab or service workers may clean up relatively small spills of relatively nondangerous, nontoxic materials in their immediate area. See "When to Ask for Help" above.

Each work unit must have a specific, written emergency plan in place for handling spills or releases before an employee may clean up a chemical spill. Refer to the Laboratory Safety Manual for a complete list of emergency plan requirements.

All employees responding to spills must be fully trained in accordance with the department's emergency plan.

University personnel from locations outside the immediate work area may not respond to or clean up a chemical spill unless they are trained and certified in an EPA/DOE approved and certified course. EH&S spill responders have completed such training. A supervisor may not identify an employee as a chemical spill management employee unless the employee has completed certified training.

See EH&S for information concerning certified chemical spill management training.
Cleanup and Disposal
EH&S-trained laboratory or service workers may use neutralizing or absorbent materials, or mechanical devices to clean up the contaminant.

Place cleanup materials and contaminants in appropriate waste containers and dispose of as required. See 5.66.
Reporting
Trained laboratory or service workers performing spill cleanup must report the spill to EH&S to properly document the incident.

EH&S is solely responsible for reporting chemical releases to regulatory authorities when required by law.
Reoccupation
Prior to reoccupation, EH&S performs area monitoring as appropriate to determine whether harmful residual contamination exists.

If necessary, EH&S initiates special decontamination procedures to ensure that the health and safety of future occupants of the site will not be compromised. After decontamination, EH&S performs further environmental monitoring to ensure that the area is suitable for reoccupancy.
Records Maintenance
Regulatory agencies require that the University maintain records of spill management activity. Departments performing spill control maintain the records; otherwise, such records are maintained by EH&S. See BPPM 90.01.

Spill management records must include the following information:
Medical Surveillance Records
Human Resource Services (HRS) maintains medical surveillance records for employees who may be exposed to chemicals through cleanup or other activities.

Contact HRS for assistance; telephone 335-4521.